Team-BHP - Auto Lighting thread : Post all queries about automobile lighting here

Quote:

Originally Posted by greenhorn (Post 943491)

souljah, shouldnt the lights be angled more to the left ? from what i see , the pattern looks like

_/_/

when it should be like
\_\_

not a matter of concern for you, but the for the people coming your way :)

Hmmm, not sure how you deduced that because its easy to adjust beam cutoff in a projector setup not in the regular HL. Anyhow like I said I need to fine tune a little more.

Quote:

Originally Posted by lohithrao (Post 944101)

Guys please suggest me a good bulb for my Advy? how much does OSram cost? or shall i stick with Phillips??

Any other thing to be considered while converting to 90/100??

Lohithavare, If the adventure is on the same platform as Petra/Palio then it would use an H1 Low/H7 High beam setup.

If its H4 then go for 100/90 philips rally or Hella's. Just goto a reputed shop though. Most stuff in original packaging also is often duplicates.

Quote:

Originally Posted by s0uljah (Post 944114)

Thumba thanks kanre:) i think its H1 & H4?? not sure getting it done in RAC hope they have a good source to get the original bulbs?

Tried everything in H4 ranging from stock 60/55W bulbs to 130/100W philips rally bulbs on my ride. I guess the best bet would be to stay with 100/90W rally series from philips or 100/80W offroad series from osram. Just installed these osrams today and eagerly waiting to check them out at night. Found that the philips rally 130/100 range are the brightest i have seen until now. Extreme power n illumination but sadly dont last for long. The bulbs blacken very quickly specially if using hi beams a lot. This reduces the light intensity in just a few days. Also they heat up the headlamp lens enough to fry an egg on :). The lens cannot be touched in as short as five minutes after switching on if the vehicle is not moving. Vehicles having plastic components in the assembly may have problem with these bulbs. Also loads up the alternator quite a bit. Also tried out the chines ones which mention 135/150 and so on. Very pathetic with those. Would be best to stay away from them. I got them off ebay for 400 bucks a pair. Took them out n installed osram offroad 100/80. Will add more on the osram offroad performance after checking them out tonight.

Quote:

Originally Posted by Meer (Post 944730)

All

I had Philips HID 6000K installed on my SX4. Yet to check it at night but even in the day, I could see the lights clearly so hoping for a super effect. Its 35W, so no tension of bulbs conking off or the current stock wiring under strain.

Will post pics soon. It cost me back by 10K.

Cheers,
Meer

I got my hid kit for 20k bucks a year ago :Frustrati.. Seems prices have really been slashed by philips. Did you get the slim ballast with external ignitor system and hi/lo control box? or is it a single beam type..? About its performance..its awesome.. lights up the road half a km in front of you.. how about your experience with the sx4 reflectors? Ive installed mine on the baleno. Had to re-aim the headlights myself after fixing it cos the hid tube comes with a glare shield which was not present on the original H4 bulbs.

Tried out my new bulbs and found them excellent.. The difference between this and the more powerful 130/100 is really not that noticable. The beam travels far n quite wide. Blind spots are minimum. I felt the philips 130/100 did not have the spread of the osram 100/80. But this might hav been an alignment issue. The osrams also tend to heat up a bit tho not as much as 130/100. The beam spread and focussing would also depend varying from car to car. A bit more expensive compared to philips 100/90 but would recommend this bulb to all users looking for a bulb upgrade. Just hoping this would last longer than the 130/100s..

Hi Abhi,

Another query this time. I want to upgrade the bulbs in my Alto LXi from the current 60/55 W Philips Crystal Visions to a brighter 100/90 W bulb.

Kindly give me your suggestions on which bulb to choose.

Also, you mentioned that you have a 100/90 installed in your Alto, so, I just want to know if this high power bulb has led to darkening/blackening of your reflectors and dulling of the plastic headlamp cover.

Please note that my Alto LXi comes with plastic headlamp covers and I'm not sure if I should go in for a high power bulb because it might damage the reflectors and plastic headlamp covers in the long run.

Your inputs on this will be greatly appreciated.

Thanks,

Pritish

Quote:

Originally Posted by akroy (Post 320091)

I have 100/90W Phillips Rally...Cost:155 / bulb. + Rally (around 250)
Excellent for highways. I used it for the highways trips. Total cost was around 600 odd rupees.
It nullifies the on coming traffic a lot but make sure u dont put it on while the car is halted for longer time as it gets damn hot and might melt the area adjacent to the bulbs (as suggested by MASS). Dont cross more than 100/90 W for an Alto. This is the best wattage for upgradation.

Infact I am thinking of putting the 60/55 W stock kit too for city use and the 100/90 for highways and higher speeds.

Abhi

OHH yes, relay is used because the stock wiring is designed only for 60W power. Higher power at same voltage means higher current, hence bigger wiring crosssection (P = V * I) to support that current.

Abhi

Just caught hold of the bill, i have done in Surakshaa, MASS, bangalore

1) Wiring Harness - 190
2) Headlight relay - 217
3) Bulbs(2) - 276 (i got discount as MRP was 155 / bulb)
4) 30 amps fuse - 42
5) Labour - 150
---------------------------------
Total - 875 + some tax

Abhi

Guys, I need help with this ASAP. I have fitted my civic with projector Headlights with 6000k HID's in the low beams but the visibility is very very poor. I can't see any thing in front of the car, but on the sides, visibility is great..
Can someone please guide me how to focus/ adjust the focus of the lights as there is very little space in the civic to put in my hand to adjust . Besides, i was not able to find any knob for the focusing.

Quote:

Originally Posted by Meer (Post 944730)

I would like to know the legal angle of driving with 6000k HID in cities. Also can you give me the address of the philips dealer from which you bought it.